Skip to main content

View Diary: Just how bad was the safety equipment at Texas fertilizer plant? (136 comments)

Comment Preferences

  •  Have you seen the process? (2+ / 0-)
    Recommended by:
    Silvia Nightshade, Penny GC

    Here's the process:

    Raw Materials Preparation: to begin the process, air is filtered and compressed, water is clarified and demineralized, and natural gas is heated and desulfurized.
    Hydrogen Generation: steam and natural gas are fed into a Primary Reformer, a reactor furnace containing several hundred alloy tubes filled with catalyst. The catalyst promotes the chemical reaction of the mixture. The products of this reaction – hydrogen, carbon oxides, and un-reacted steam and methane – are directed to a Secondary Reformer, where compressed air is added to produce what’s called process gas.

    Process Gas Purification: the process gas next flows through high- and low-temperature Shift Converters, which convert the carbon monoxide into carbon dioxide (CO2) and hydrogen. CO2 is removed from the process gas; a portion of it is recovered for use in the production of urea.

    The remaining purified process gas, a 3-to-1 mixture of hydrogen and nitrogen called synthesis gas, is used to produce ammonia.

    Ammonia Synthesis: the synthesis gas is compressed and circulated through an Ammonia Converter, where each pass through the synthesis catalyst converts a portion of the gas to ammonia.

    Refrigeration: condensed by refrigeration, ammonia is then removed from the synthesis gas. The product is withdrawn in a “warm” stream at 13° C (used for urea production) and as a “cold” liquid at minus 33° C (sent to storage).

    The anhydrous and the methane used to create it are stored under pressure.  Any time you're primary raw material is methane and you have no fire suppression system, as was the case in West, you are courting disaster.

    "Some folks rob you with a six-gun, some rob you with a fountain pen." - Woody Guthrie

    by Involuntary Exile on Thu Apr 18, 2013 at 05:24:36 PM PDT

    [ Parent ]

    •  i suspect the ammonia was the issue. (2+ / 0-)
      Recommended by:
      Bulldozer, Silvia Nightshade

      a fire starts somewhere, it starts burning the ammonia tank heats, begins venting, but the tank splits and then blows as the boiling ammonia spreads out and goes.

      but who knows, the engineers will figure out what the explosion was based upon signature, blast pattern and
      heat signature.

      the picture i saw was a rich orange fire,  usually methane burns clear blue.

Subscribe or Donate to support Daily Kos.

Click here for the mobile view of the site